Service Manual
29 Pages
Preview
Page 1
Golvo 8000 / 8008 Service Manual
English
Prod. No.
2000014 2000015 2000019 2000024 2000025
Golvo 8000 Golvo 8008 Golvo 8008 LowBase Golvo 8000 Classic Golvo 8008 Classic
Golvo with fixed hand control: Prod. No. 2000034 Golvo 8000 2000035 Golvo 8008 2000039 Golvo 8008 LowBase 3EN400404-02 2012-12-28 Proj. 1728,1707
Golvo 8000 / Golvo 8008
Golvo 8008 LowBase
Golvo 8000 Classic / Golvo 8008 Classic
© Copyright Liko AB
Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. For information regarding Service and Maintenance education, contact your Hill-Rom/Liko representative. For contact information please visit our website: www.liko.com
Liko AB • Nedre vägen 100 • SE-975 92 Luleå • Sweden tel +46 (0)920-47 47 00 • fax +46 (0)920-47 47 01 [email protected] • www.liko.com
Table of Contents 1.0 2.0 3.0
Page
Table of contents ...3 Spare Parts Position...5 Technical Data 3.1 Measurments Golvo 8000/8008... 7 3.2 Measurements Golvo 8000 Classic/ 8008 Classic... 8 3.3 Golvo with IR hand control... 9 3.4 Golvo with fixed hand control... 10 4.0 Troubleshooting 4.1 Golvo with IR hand control... 11 4.2 Golvo with fixed hand control...12 4.2 CBL20 12 ...13 5.0 Spare Parts Data (Spare Parts/Golvo model)...14 5.0 Spare Parts List (Spare Parts information)...18 5.12 Emergency Lowering Device Golvo, grey...26 5.13 Body/Handle set for Emergency Lowering Device .28 5.14 Lift Strap G7 / G8...30 5.20 Hand control 6-Button...32 5.33 Gear Rack set ...33 5.36 Spring Magazine...35 5.159 Front Fork Cover ...36 5.185 Lift Strap G77 ES / G88 ...37 5.250 Reinforcement Plate Golvo...39 5.264 Latch Universal Sling bar...40 5.274 Motor for Base Width Adjustment Golvo, grey...41 5.275 Plastic Housing, grey...42 5.279 Roll Frame Attachment Golvo, grey...44 5.280 Base Motor Cover, grey...45 5.284 Front Wheel 75 mm Standard...46 5.285 Rear Wheel 75 mm Standard...47 5.292 Hook for Hand control...48 5.293 End Cover Handle/Arm Support, grey...49 5.294 End Cover Armrest, grey...50 5.311 Latch, composite...52 5.323-324 Easy Strapper G7 / G8...53 5.330 Golvo 7007 / 8008 LowBase kit...54 5.333 Wireless Hand control HBL...56 5.336 Control Unit by S/N...57 5.336C Control Unit by S/N, Cable...59 5.348-349 Extension cable CBL...61 5.350 Extra Battery Box...62 5.351 Beltclip HBL20...63 5.352 Clips with hook HBL20...64 5.353 Charge Cable Hook...65 5.354 Hand control hanger...66 5.397 Q-link...67 5.398 Lift strap joint...69 5.404 Friction plates 2.8-3.4 mm...71 5.411 Control Unit CBL, Golvo...73 5.411C Control Unit CBL, Golvo cable...75 5.419 Adapter Golvo (for Scale)...77 5.420 Limit Switch Box...78 5.421 Limit Switch PCBA...79 5.422 Locking device CBL20...80 5.423 Actuator G8 / G88...81 5.485 Fork locking attachment...83 5.486 Wheel Fork...84 5.487 Parking bracket...85 5.490 SlingBar Assembly set...86 5.492, 496 Lift Strap Cover Strip ...87 5.511 Locking Ring CBL...88 6.0 Service, Control Unit CBL 6.1 Parameter Code Key... 89 6.2 Reset Service Interval Parameters... 90 7.0 Liko Service System...91 8.0 Liko Diagnostic System - Service...92 9.0 Periodic Inspection...93 10.0 Preventative Maintenance...97 11.0 Product Changes ...107
Golvo 8000, Golvo 8008, Golvo 8008 LowBase, Golvo 8000 Classic, Golvo 8008 Classic
1.0
Spare Parts
Spare Parts Position PROD. NO.
PRODUCT
PROD. NO.
PRODUCT
2000050
Golvo 7000ES Classic
2000061
Golvo 7007 LowBase
2000051
Golvo 7007ES Classic 279
492 496
279
492
250
250
185 324
14 185 323 324
275 36
264
12 13
311
275
490
293
36
264 311
487
293
12 13
294
487
139 293
139 11 18
11
19
33 404
19
18
33 251
274 280
404
274 280
251
159 485 486
159 485 486 285
285
160 263
22 23 24 248
160 263
284
22 23 24 248
PROD. NO.
PRODUCT
2000019
Golvo 8008 LowBase (intelligent control box)
2000039
Golvo 8008 LowBase (intelligent control box and cable hand control) 279
492 250 397
419
398
490 36 275 12 13 294
490 20
264 311 354
333 351 352 511
354
487 293
422
292
350
336 411
274 280
185 324
420 421
423 33 404
159 485 486
285
330
Doc. No. 3EN800804-01
12 5
www. liko.com
www.liko.com
2.0
Spare Parts
Spare Parts Position PROD. NO.
PROD. NO.
PRODUCT
PRODUCT
2000024 Golvo 8000 Classic (intelligent control box) 2000025 Golvo 8008 Classic (intelligent control box)
2000014 Golvo 8000 (intelligent control box) 2000015 Golvo 8008 (intelligent control box) 2000034 Golvo 8000 (intelligent control box and cable hand control) 2000035 Golvo 8008 (intelligent control box and cable hand control) 279
492 496
279
492 496
250
250
14 185 323 324
14 185 323 324 490
490
264 311
264 311 36 275
36 275 354
12 13
354
333 351 352 511
354
294
12 13
487
293 333 351 352 511
354
293
420 421
420 421 422
487
422
350
350
423
423 336 411 411C
336 411
33 404
274 280
274 280
285
33 404
285
159 485 486
159 485 486
284
284
Service Tools, see page 79 397
419
398
490 20
Liko Service System
292
Liko Diagnostic System
348 349
330
Doc. No. 3EN800804-01
13 6
www.liko.com
www.liko.com
3.1 Technical Data Golvo 8000 / 8008 Dimensions Top view
700 mm (27.5 in)
Lateral view
M
D C
A D2 O
Lmax E
Lmin
EG
Golvo LowBase 600 mm (23.6 in)
F1 F
B3 B2 B1 B
B4
Maximum reach
Table of measurements Model
A
C
D
B1
B2
B3*
B4
Golvo 8000
1995 1360 1115 800
435
435
-
938
654
826
Golvo 8008
2090 1455 1185 870
480
480
-
1020 735
Golvo LowBase
2090 1455 1185 870
480
480
600 1028 745
max. min.
B
(mm) D2*
E
F
F1
G
Lmax Lmin
M
O
543
0
975
105
25
840
1735
475
440
362
907
623
0
1100
105
25
940
1860
600
436
391
907
623
0
1100
60 / 105
22
940
1860
600
436
391
max. min. max. min.
(Inch.) Model
A
B3*
B4
B
B1
B2
Golvo 8000
78.5 53.5 43.9 31.5 17.1 17.1
-
Golvo 8008
82.3 57.3 46.6 34.2 18.9 18.9
-
Golvo LowBase
C
D
D2*
E
F
F1
G
Lmax Lmin
M
O
36.9 25.7 32.5 21.4
0
38.4
4.1
1.0
33.0
68.3
18.7
17.3
12.8
40.2 28.9 35.7
623
0
43.3
4.1
1.0
37
73.2
23.6
17.2
15.4
82.3 57.3 46.6 34.2 18.9 18.9 23.6 40.5 29.3 35.7
623
0
43.3
2.4 / 4.1
0.9
37
73.2
23.6
17.2
15.4
max. min.
max. min. max. min.
The lifting interval 1260 mm (50 inch.) is height-adjustable,.see page 9. Lifting height dimensions are based on the lift being equipped with a standard sling bar and standard wheels. When changing to other lifting accessories, check that the lift still achieves the desired lifting height. * Reference measurement according to Standard EN ISO 10535:2006.
7
Golvo • 7EN140105-02
4
www.liko.com
w w w . l i k o . com
3.2 Technical Data Golvo 8000 Classic / 8008 Classic Dimensions Top view
700 mm 700 mm (27.5 in) (27.5 Inch.)
Lateral view
M
D C
A D2 O
Lmax Lmin
EG 600 mm 600 mm (23.6 in) (23.6 Inch.)
E
F1 F
B3 B2 B1 B
Maximum reach
Table of measurements Model
A
C
D
B1
B2
B3*
B4
Golvo 8000
1995 1360 1115 800
435
435
-
938
654
826
Golvo 8008
2090 1455 1185 870
480
480
-
1020 735
907
max. min.
B
(mm) D2*
E
F
F1
G
Lmax Lmin
M
O
543
0
975
105
25
840
1735
475
440
362
623
0
1100
105
25
940
1860
600
436
391
max. min. max. min.
(Inch.) Model
A
B3*
B4
Golvo 8000
78.5 53.5 43.9 31.5 17.1 17.1
-
Golvo 8008
82.3 57.3 46.6 34.2 18.9 18.9
-
max. min.
B
B1
B2
C
D
D2*
E
F
F1
G
Lmax Lmin
M
O
36.9 25.7 32.5 21.4
0
38.4
4.1
1.0
33.0
68.3
18.7
17.3
12.8
40.2 28.9 35.7
0
43.3
4.1
1.0
37
73.2
23.6
17.2
15.4
max. min. max. min.
623
The lifting interval 1260 mm (50 inch.) is height-adjustable,. see page 9. Lifting height dimensions are based on the lift being equipped with a standard sling bar and standard wheels. When changing to other lifting accessories, check that the lift still achieves the desired lifting height. * Reference measurement according to Standard EN ISO 10535:2006.
8
www.liko.com
Technical Data Golvo 8000 /Definitions 8008 with IR Hand Control Technical Data
Golvo 8000/8008 Classic 200 kg (440 lbs)
Maximum load: Material:
Anodised aluminium
Weight:
8000: 42 kg (92 lbs) 8008: 44 kg (97 lbs) 8008 LowBase: 46 kg (101 lbs) 1 Heaviest removable part: 8000: 18 kg (40 lbs) 2 8008: 19 kg (42 lbs) 8008 LowBase: 21 kg (46 lbs)
17
16
Wheels:
Operating forces, controls:
1. Lift Strap HandControl IR: Batteries: 2 AAA LR03 1.5 V, alkaline. 2. Sling bar withReach: latches2 m (78.74 inch.)
3. HandControl IR V Electrical data: 24 4. Parking panel for sling bar Intermittent Int. Op 10/90, active operation max 2 min. 5. Holder for Quick Guidelength and colour code operation: OnlyReference 10% of a given of time may for sling sizesbe active, yet no more than 2 min. 6. Product decalNiMH cells, 2.2 Ah. New batteries Battery: by the supplier. 7. Lift mast withprovided inbuilt motor
3
15
14
Turning diameter: 13 12
Front: 75 mm* (3 inch.) twin wheels. *Golvo LowBase: 46 mm (1.8 inch.) twin wheels. Rear: 75 mm4 (3 inch.) twin wheels with brakes
8. charger: Front wheelsCBL20001, built-in, 100-240 V AC, Battery 50-60 Hz, max 600 mA. 9. Base
5
Golvo 8000: 1240 mm (49 inch.) Golvo 8008: 1330 mm (52 inch.) 6 Golvo 8008 LowBase: 1330 mm (52 inch.) 7
Lift motor: V,brakes 6.5 A 10. Rear wheels 24 with 11.forMotor Motor base-for base-width adjustment width adjustment: 24 V,emergency 3.5 A 12. Control box with stop built-in charger and operation panel (electrical emergency lowering/raising)
Forward direction
Emergency lowering11device:
Mechanical and electrical
Lifting speed 10 with no load:
Two speeds; 41 mm/s (1.61 inch/s) and 33 mm/s (1.3 inch/s)
9 Lifting interval:
1260 mm (50 inch.) (height-adjustable)
Sound level:
52,8 dB(A)
Protection class:
IP X4
Buttons on hand control: 4 N Button on display: 4 N
13. Control box IR receiver The device is intended for use indoors. 14. Battery TypeHandles B, in accordance with the electrical shock 15. 16. Emergency protection class.Lowering (mechanical) 17. Lift arm Class II equipment.
8
Protected by Patent w w w . l i k o . com
3
Golvo • 7EN140105-02
Technical Data Golvo 8000 Classic / 8008 Classic with IR Hand Control Technical Data Maximum load:
200 kg
Electrical data:
24 V
Material:
Anodised aluminium
Weight:
Golvo 8000 Classic: 39 kg (86 Ibs) Golvo 8008 Classic: 41 kg (90 Ibs) Heaviest removable part: Golvo 8000 Classic: 18 kg (40 Ibs) Golvo 8008 Classic: 19 kg (42 Ibs)
Intermittent operation:
Int. Op 10/90, active operation max 2 min. Only 10% of a given length of time may be active, yet no more than 2 min.
Battery:
NiMH cells, 2.2 Ah. New batteries provided by the supplier.
Battery charger:
CBL20001, built-in, 100-240 V AC, 50-60 Hz, max 600 mA.
Lift motor:
24 V, 6.5 A
Motor for basewidth adjustment:
24 V, 3.5 A
Wheels:
Turning diameter:
Front: 75 mm* (3 inch.) twin wheels. Rear: 75 mm (3 inch.) twin wheels with brakes Golvo 8000 Classic: 1240 mm (49 inch.) Golvo 8008 Classic: 1330 mm (52 inch.)
Emergency lowering device:
Mechanical and electrical
Lifting speed with no load:
Two speeds; 41 mm/s (1.61 inch/s) and 33 mm/s (1.3 inch/s)
Lifting interval:
1260 mm (50 inch.) (height-adjustable)
Sound level:
52,8 dB(A)
Protection class:
IP X4
Operating forces, controls:
Buttons on hand control: 4 N Button on display: 4 N
HandControl IR:
Batteries: 2 AAA LR03 1.5 V, alkaline. Reach: 2 m (78.74 inch.)
Golvo Classic • 7EN140106-02
The device is intended for use indoors. Type B, in accordance with the electrical shock protection class. Class II equipment. Protected by Patent
93
www.liko.com w w w . l i k o . com
Technical Data Golvo 8000Technical / 8008, with fixed Hand Control Data Maximum load:
200 kg (440 lbs)
Material:
Anodised aluminium
Weight:
8000: 42 kg (92 lbs) 8008: 44 kg (97 lbs) 8008 LowBase: 46 kg (101 lbs) Heaviest removable part: 8000: 18 kg (40 lbs) 8008: 19 kg (42 lbs) 8008 LowBase: 21 kg (46 lbs)
Wheels:
Turning diameter
Operating forces, Buttons on hand control: 2.4 N controls: Button on display: 4 N
Front: 75 mm* (3 in) twin wheels. *Golvo LowBase: 46 mm (1.8 in) twin wheels. Rear: 75 mm (3 in) twin wheels with brakes.
Mechanical and electrical
Lifting Speed no load
Two speeds; 41 mm/s (1.61 in/s) and 33 mm/s (1.3 In/s)
Lifting interval:
1260 mm (49.6 in) (height-adjustable)
Sound level:
52.8 dB(A)
Protection class:
IP X4
Golvo • 7EN140107-01
24 V
Intermittent power:
Int. Op 10/90, active operation max 2 min. Only 10% of a given length of time may be active, but no more than 2 min.
Battery:
NiMH cells, 2.2 Ah. New batteries provided by the supplier.
Battery charger:
CBL20002, built-in, 100-240 V AC, 50-60 Hz, max 600 mA.
Lift motor:
24 V, 6.5 A
Motor for basewidth adjustment: 24 V, 3.5 A
Golvo 8000: 1240 mm (49 in) Golvo 8008: 1330 mm (52 in) Golvo 8008 LowBase: 1330 mm (52 in)
Emergency lowering device:
Electrical data:
The device is intended for use indoors. Type B, in accordance with the electrical shock protection class. Class II equipment. Protected by Patent
3
w w w . l i k o . com
10
www.liko.com
4.1 Troubleshooting Golvo 8000/8008 with IR Hand control Simple Troubleshooting The lift cannot be controlled via HandControl IR.
1. Check that the emergency stop has not been activated. 2. Make sure that the charging cable is not connected to an electric outlet. 3. Check if HandControl IR indicates battery change. 4. If the lift has been inactive for 24 hours, enable the system, press optional button on the operation panel. 5. Make sure that the HandControl IR control is enabled. 6. If the problem remains, see “The lift cannot be controlled via the operation panel”, below.
The lift cannot be controlled via the operation panel.
1. Make sure that the emergency stop has not been activated. 2. Check that the charger cable is not connected to an electric outlet. 3. Check the battery capacity. 4. Make sure that the cables to the control box are connected correctly. 5. Check that the battery’s contact plates are not defective or broken. 6. If the problem remains, please contact Liko/Hill-Rom.
The charger doesn’t work.
1. Make sure that the emergency stop has not been activated. 2. Make sure that the battery is properly attached. 3. Check that the battery pack’s contact plates are not defective or broken. 4. If the problem remains, please contact Liko/Hill-Rom.
The lift is stuck in the high position.
1. Make sure that the emergency stop has not been activated. 2. Check the battery capacity. 3. HandControl IR indicates battery change. 4. Use the indicated electrical emergency lowering to lower the patient onto a firm surface. 5. Use the indicated mechanical emergency lowering to lower the patient onto a firm surface. 6. If the problem remains, please contact Liko/Hill-Rom.
The lift does not reach maximum lifting height.
1. Check that the lifting interval level is correctly set. 2. If the problem remains, please contact Liko/Hill-Rom.
If you hear unusual sounds.
Contact Liko/Hill-Rom.
11
www.liko.com
4.2 Troubleshooting Troubleshooting GolvoSimple 8000/8008 with fixed Hand Control The lift cannot be operated with the hand control.
1. Check that the emergency stop button has not been pressed. 2. Check the battery capacity. 3. Check that the charger cable is not connected to an electric outlet. 4. Check that the hand control cable is correctly connected. 5. If the lift works via the operation panel, change the Hand Control. 6. If the problem persists, please contact Liko/Hill-Rom.
The lift does not work up/down with the operation panel. The base-width adjustment doesn’t work (in/out) with the operation panel.
1. Check that the emergency stop button has not been pressed. 2. Check that the cables to the control box are connected correctly. 3. Check that the charger cable is not connected to an electric outlet. 4. Check the battery capacity. 5. If the problem persists, please contact Liko/Hill-Rom.
The charger doesn’t work.
1. Check that the emergency stop button has not been pressed. 2. Check that the charger cables are connected correctly. 3. Make sure that the battery is properly attached. 4. If the problem persists, please contact Liko/Hill-Rom.
The lift is stuck in the high position.
1. Check that the emergency stop button has not been pressed. 2. Check the battery capacity. 3. Check that the hand control cable is connected correctly. 4. Electrical emergency lowering, use the operation panel to lower the patient onto a firm surface. 5. Use the mechanical emergency lowering device to lower the patient onto a firm surface. 6. If the problem persists, please contact Liko/Hill-Rom.
The lift does not reach maximum lifting height.
1. Check that the lifting interval level is correctly set. 2. If the problem persists, please contact Liko/Hill-Rom.
If any noises are heard.
Contact Liko/Hill-Rom.
12
www.liko.com
8 Battery
4.3
Contract No:
Trouble Shooting for CBL20 Troubleshooting
Name:
Address: Tools Required
(Zip Code) Note! Begin with Simple trouble shooting from Service manual for the actual product. If problem remains continue as described below.
Tools required
Multimeter
Instructions regarding the check points for Viking M Lift type:
Serial No:
Prod. Year:
Check point: 1.
Make sure that:
- the8 Battery emergency stop 1 is not activated. - the battery is assembled correctly. - the charging cable is not connected to mains.
Contract No:
Name: Ah 140 280 420 560 700 Check: Address: Replace: (Zip Code)
2.
Check operation panel function´s for actuator and base motor Push control buttons on operation panel 2 at control box Tools required
- If both actuator and base motor functions response, continue to step 5.
green, LED
- If no function, continue to step 3.
2
- If only one of either the actuator or base motor function response: change position on actuator and base motor cables then check control function of operation panel, to see if fault is on output channels or the motors. If control box function is ok! Continue to step 5. If control box is faulty. Replace the control box.
3
yellow, LED
4
3
1
1 Battery capacity Check battery capacity by pressing the i button (1). The following information is displayed: 2 – Green light: More than 50% of battery capacity remaining. 3 – Yellow light: 25% -50% of battery capacity remaining. 4 – Yellow light: 0% -25% of battery capacity remaining. The indicator lamps light for about 30 seconds before switching off. Battery capacity is also displayed during lift operation.
2
3.
Check battery capacity
3a)
Push in the battery capacity button 3 : - If any of the three LED´s on the battery start´s the battery is OK, continue to step 4. - If not, continue to step 3b.
3b)
Measure battery voltage: release battery, 4 measure on contact 1 and 3: - If voltage over 0V the battery is ok! Continue to step 4.
4.
Verify contact between control box and battery.
Maximum charge is reached after about 5 hours. When the batteries are fully charged, the charger switches automatically to maintenance charging.
4a) Remove the battery and wait for green LED to turn off.
The lamps blink alternately (yellow/yellow/green) during charging. A blinking green lamp indicates that charging is complete. When operating time is noticeably shorter than normal, the batteries should probably be replaced. Discontinue charging and replace the batteries with 2006107 Extra battery box.
4b)
Put back the battery and see if green LED start automatically. - If green LED starts, battery contact is ok! - If not, try to ensure that the battery´s contact plates are not defective or broken and try to bend them out carefully, then repeat step 4.
off.
- If still no contact, continue to step 5.
1 2 3 1 2 3
Prod. No. 2006107 Extra battery box
5.
Check charging function
5a)
Connect the charging cable to mains - If charging starts within 1 minute, charge and then continue to step 6.
4
5
- If charging doesn´t start, continue to step 5b. 5b)
eries are fully charged, the charger switches
14
www.liko.com Measure output voltage on the control box 5 on contact 1 and 3.
- If voltage is 3-4V charging is OK! Replace the battery, continue to step 6. - If voltage is 0V when the charging cable is connected to mains the control box needs to be replaced! Replace the control box.
g. A blinking green lamp indicates that charging 6. Charge the battery until green LED is flashing, on the battery. mal, the batteries should probably be replaced. - Check that all function´s on the control box is ok! If not , Replace control box. Customers tra battery box.FAQ: - The liftarms up/down function or base width in/out function doesn´t work? a) Change position on actuator and base motor cables. b) Perform step 2 and see if fault is on output channel or motors.
- The control panel function´s on controlbox is ok, but the hand control has no function? a) Check to ensure that battery contact plates in the hand control are not defective or broken. - There´s no charging function? a) Verify contact between control box and battery. Perform step 4. b) Check charging function. Perform step 5. 3EN902101-01
13
www.liko.com
Doc. No. 3EN800804-01
14 14
19
20
22
23
24
29
30
31
32
33
34
20090022
20090023
20090089
20090026
20090027
20090028
20090034
20090035
20090036
20090037
20090038
20090039
38
18
20090020
20090043
16
20090019
37
15
20090018
20090042
14
20090016
36
13
20090015
20090041
12
20090014
35
11
20090013
20090040
4
10
20090004
3
Front Wheel 100 mm
Front Wheel 50 mm
Spring Magazine
End Cover Armrest
End Cover Handle/Arm Support
Gear Rack set G7 / 77
Rear Fork Cover G7 / 77
Front Fork Cover G7 / 77
Rear Wheel 100 mm
Front Wheel 75 mm
Cable for charging US
Cable for charging UK
Cable for charging EU
Hand Control 6-Button
Attachment for Control Box
Control Box G7-77 ES
Roll Frame Attach. G7 / 77
Lift Strap G77
to S/N 7723629
Lift Strap G7/G8
Body/Handle set for Em.Low. Device G7 / 77
Emergency Lowering Device Golvo, grey
Actuator G7 / 77
Armrest complete G7 / 77
Middle Beam G77
Middle Beam G7
POS. NAME NO.
20090003
SPARE PART NO.
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
(x)
x
x
x
x
x
7007 ES to S/N 7729721
7000 ES to S/N 7024205
x
x
x
x
x
x
x
x
x
x
x
x
7000 ES fr. S/N 7024206 (Face lift)
2000010 2000009
2000009
x
x
x
x
x
x
x
x
x
x
x
7007 ES fr. S/N 7729722 (Face lift)
x
x
x
x
x
x
x
x
x
x
x
x
7000 ES Classic
2000010 2000050
x
x
x
x
x
x
x
x
x
x
x
7007 ES Classic
x
x
x
x
x
x
x
x
x
x
x
7007 LowBase
2000051 2000061
x
x
x
x
8008 LowBase
2000019
x
x
x
x
x
8008 LowBase Cable
x
x
x
x
x
8000
2000039 2000014
x
x
x
x
x
x
8000 Cable
x
x
x
x
8008
2000034 2000015
x
x
x
x
x
8008 Cable
2000035
x
x
x
x
x
8000 Classic
2000024
x
x
x
x
8008 Classic
2000025
Golvo - Spare Parts data 5.0
www.liko.com
w w w . liko. com
Doc. No. 3EN800804-01
39
40
79
86
87
139
159
160
185
218
248
250
251
263
264
274
275
279
280
284
285
292
293
294
20090045
31190008
20190078
31190018
2006106
20390006
21090001
20090048
20090049
20090050
20090051
20090052
15 15
21090011
31590011
20090059
20090060
20090064
20090065
20490014
20490015
20090058
20090066
20090067
End Cover Armrest, grey
End Cover Handle/Arm Support, grey
Hook for Hand control
Rear Wheel 75 mm , Std
Front Wheel 75 mm Standard
Base Motor Cover, grey
Roll Frame Attachment Golvo, grey
Plastic Housing, grey
Motor for Base with Adjustment Golvo, grey
Latch Universal SlingBar
Extension Cable US
Limit Switch G7 / 77
Reinforcement Plate
Cable for Charging AU/NZ
Base Motor Cover
Lift Strap G77 ES /G88
Extension Cable
Front Fork Cover
Extra Battery
Safety Latch
SlingBar Standard 450
Plastic Housing
Rear Wheel 125 mm
Rear Wheel 75 mm
POS. NAME NO.
20090044
SPARE PART NO.
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
7007 ES to S/N 7729721
7000 ES to S/N 7024205
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
7000 ES fr. S/N 7024206 (Face lift)
2000010 2000009
2000009
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
7007 ES fr. S/N 7729722 (Face lift)
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
7000 ES Classic
2000010 2000050
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
7007 ES Classic
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
7007 LowBase
2000051 2000061
x
x
x
x
x
x
x
x
x
x
x
8008 LowBase
2000019
x
x
x
x
x
x
x
x
x
x
x
x
8008 LowBase Cable
x
x
x
x
x
x
x
x
x
x
x
8000
2000039 2000014
x
x
x
x
x
x
x
x
x
x
x
x
8000 Cable
x
x
x
x
x
x
x
x
x
x
x
x
8008
2000034 2000015
x
x
x
x
x
x
x
x
x
x
x
x
x
8008 Cable
2000035
x
x
x
x
x
x
x
x
x
x
8000 Classic
2000024
x
x
x
x
x
x
x
x
x
x
x
8008 Classic
2000025
Golvo - Spare Parts data 5.0
www.liko.com w w w. liko. com
Doc. No. 3EN800804-01
311
323
324
330
333
336
336C Control Unit CBL by S/N, cable
348
349
350
351
352
353
354
397
398
404
411
411C Control Unit CBL, Golvo Cable
413
419
420
421
422
31590014
20090069
20090070
20090071
20490031
20490039
20490054
21090018
21090019
2006107
21090020
21090021
16 16
21090022
21090023
31590005
31590025
20090072
20090073
20090088
20490037
2006010
20090074
20090076
20090077
Locking device CBL20,
Limit Switch PCBA
Limit Switch Box
Adapter Golvo (for Scale)
Rear Wheel fork
Control Unit CBL, Golvo
Friction plates 2,8-3,4 mm
Lift strap joint
Q-link
Hand control hanger
Charge cable hook
Clips with hook HBL20
Beltclip HBL20
Extra Battery Box
Extension cable CBL20, US
Extension cable CBL20
Control Unit CBL, by S/N
Wireless hand control HBL20
Low base kit Golvo 7007/8008
Easy Strapper G77/G88 from S/N 7723630
Easy Strapper G7/G8
Latch, composite
POS. NAME NO.
SPARE PART NO.
x
x
x
x
x
x
x
x
x
x
x
x
x
7007 ES to S/N 7729721
7000 ES to S/N 7024205
x
x
x
x
x
x
7000 ES fr. S/N 7024206 (Face lift)
2000010 2000009
2000009
x
x
x
x
x
x
x
7007 ES fr. S/N 7729722 (Face lift)
x
x
x
x
x
x
7000 ES Classic
2000010 2000050
x
x
x
x
x
x
x
7007 ES Classic
x
x
x
x
x
x
x
7007 LowBase
2000051 2000061
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
8008 LowBase
2000019
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
8008 LowBase Cable
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
8000
2000039 2000014
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
8000 Cable
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
8008
2000034 2000015
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
8008 Cable
2000035
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
8000 Classic
2000024
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
8008 Classic
2000025
Golvo - Spare Parts data 5.0
www.liko.com w w w. liko. com
Doc. No. 3EN800804-01
423
425
485
486
487
490
492
496
511
512
514
515
516
20090078
21090028
20090080
20090081
20090082
20490052
20090085
20090087
20490057
20490060
2006001
17 17
2004304
2004305
Wheel Set 100/125
Wheel Set 50/75
Parking Hook for SlingBar
Front Wheel Fork
Locking Ring CBL
Lift strap Cover Strip 7000/8000
Lift strap Cover Strip 7007/8008
SlingBar Assembly set
Parking bracket
Wheel Fork
Fork locking attachment
Grease SHC460 30g
Actuator G8-88
POS. NAME NO.
SPARE PART NO.
x
x
x
x
x
x
x
x
x
x
x
x
7007 ES to S/N 7729721
7000 ES to S/N 7024205
x
x
x
x
x
x
7000 ES fr. S/N 7024206 (Face lift)
2000010 2000009
2000009
x
x
x
x
x
x
7007 ES fr. S/N 7729722 (Face lift)
x
x
x
x
x
x
7000 ES Classic
2000010 2000050
x
x
x
x
x
x
7007 ES Classic
x
x
x
x
x
x
7007 LowBase
2000051 2000061
x
x
x
x
x
x
x
8008 LowBase
2000019
x
x
x
x
x
x
x
x
8008 LowBase Cable
x
x
x
x
x
x
x
x
8000
2000039 2000014
x
x
x
x
x
x
x
x
x
8000 Cable
x
x
x
x
x
x
x
8008
2000034 2000015
x
x
x
x
x
x
x
x
8008 Cable
2000035
x
x
x
x
x
x
x
8000 Classic
2000024
x
x
x
x
x
x
x
8008 Classic
2000025
Golvo - Spare Parts data 5.0
www.liko.com w w w. liko. com
Spare Parts List
5.0
Spare Parts
Golvo
(G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO.
POS. NO.
NAME
UNIT
Golvo LiftStrap 20090018
14
Lift Strap G7 / G8
pce
Grey strap and grey plastic details
20090019
15
Lift Strap G77 up to S/N 7723629
pce
20090048
185
Lift Strap G77 (from S/N: 7723630) / G88 Grey strap and grey plastic details
pce
20090069
323
Easy Strapper G7 / G8 Grey strap and grey plastic details
set
20090070
324
Easy Strapper G77 from S/N 7723630 / G88 Grey strap and grey plastic details
set
Golvo Control Units 20090022
18
Control Box G7 / 77 ES
pce
20090022US
18
Control Box G7 / 77 ES, US
pce
only for the US market
20490039
336
Control Unit CBL, by S/N Can only be ordered if S/N (serial number) can be provided to Liko Customer Service. Will be programmed at Liko before delivery.
pce
2 weeks delivery time from Liko.
Doc. No. 3EN800804-01
18 18
w w w .lik o .com
www.liko.com
Spare Parts List
5.0
Spare Parts
Golvo
(G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO.
POS. NO.
20490054
336C
NAME
UNIT
Control Unit CBL by S/N, Cable Can only be ordered if S/N (serial number) can be provided to Liko Customer Service. Will be programmed at Liko before delivery.
pce
2 weeks delivery time from Liko. 20090073
411
Control Unit CBL, Golvo Before use; requires Software and, needs to be programmed with Liko Service System, Prod. No. 21090024
pce
20090088
411C
Control Unit CBL Golvo, Cable Before use; requires Software and, needs to be programmed with Liko Service System, Prod. No. 21090024
pce
Golvo Spare Parts 20090003
3
Middle Beam G7 up to S/N 7024205
pce
20090004
4
Middle Beam G77 up to S/N 7729721
pce
20090013
10
Armrest complete G7 / 77 up to S/N 7024205 / 7729721
set
20090014
11
Actuator G7 / 77 For Golvo 7000/7007 with S/N 700001-702297 / 770001 - 771050 the mast must be modified according to the Service Manual
pce
20090015
12
Emergency Lowering Golvo, grey
pce
20090016
13
Body/Handle set for Emergency Lowering Device
pce
Doc. No. 3EN800804-01
19
19
www. liko . com
www.liko.com
Spare Parts List
5.0
Spare Parts
Golvo
(G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO.
POS. NO.
NAME
UNIT
20090020
16
Roll Frame Attachment G7 / 77 up to S/N 7024205 / 7729721
pce
20090023
19
Attachment for Control Box
pce
20090089
20
Hand control 6-Button
pce
20090026
22
Cable for charging EU
pce
20090027
23
Cable for charging UK
pce
20090028
24
Cable for charging US
pce
20090034
29
Front Wheel 75 mm up to S/N 7024205 / 7729721
pce
20090035
30
Rear Wheel 100 mm up to S/N 7024205 / 7729721
pce
20090036
31
Front Fork Cover G7 / 77 up to S/N 7024205 / 7729721
pair
20090037
32
Rear Fork Cover G7 / 77 up to S/N 7024205 / 7729721
pair
20090038
33
Gear Rack set
set
20090039
34
End Cover Handle/Arm Support up to S/N 7024205 / 7729721
set
Doc. No. 3EN800804-01
20
20
www.liko.com
www.liko.com
Spare Parts List
5.0
Spare Parts
Golvo
(G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO.
20090040
POS. NO.
35
NAME
UNIT
End Cover Armrest up to S/N 7024205 / 7729721
pair
x2 x4 20090041
36
Spring Magazine
pce
20090042
37
Front Wheel 50 mm up to S/N 7024205 / 7729721
pce
20090043
38
Front Wheel 100 mm up to S/N 7024205 / 7729721
pce
20090044
39
Rear Wheel 75 mm up to S/N 7024205 / 7729721
pce
20090045
40
Rear Wheel 125 mm up to S/N 7024205 / 7729721
pce
31190008
79
Plastic Housing up to S/N 7024205 / 7729721
pce
20190078
86
SlingBar Standard 450 up to S/N 7024205 / 7729721
pce
31190018
87
Latch up to S/N 7024205 / 7729721
pair
2006106
139
Extra Battery
pce
20390006
159
Front Fork Cover LL, Vi, Golvo from S/N 7024206 / 7729722
pair
21090001
160
Extension Cable
pce
Doc. No. 3EN800804-01
21 21
w w w .lik o .com
www.liko.com