Action³ NG User Manual Jan 2019

©2019 Invacare Corporation All rights reserved. Republication, duplication or modification in whole or in part is prohibited without prior written permission from Invacare Corporation. Trademarks are identified by ™and ®. All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise noted.

Contents 1 General... 1.1 Introduction... 1.2 Symbols in this manual... 1.3 Warranty... 1.4 Limitation of liability... 1.5 Standards and Regulations... 1.6 Intended use... 1.7 Service life...

5 5 5 6 6 6 6 7

2 Safety... 2.1 Safety information... 2.2 Safety devices... 2.3 Labels and symbols on the product...

8 8 9 9

3 Components and their functions... 11 3.1 Overview... 11 3.2 Parking brakes... 12 3.3 Backrest... 13 3.3.1 Backrest cover... 13 3.3.2 Backrest cover height... 14 3.3.3 Fixed backrest... 14 3.3.4 Folding backrest... 14 3.3.5 Reclining backrest... 15 3.3.6 Angle adjustable backrest (-15°/+15°)... 16 3.4 Backbrace... 17 3.4.1 Standard backbrace for the backrest... 17 3.4.2 Folding backbrace for the backrest... 18 3.5 Push handles... 18 3.6 Mudguard... 19 3.7 Armrests... 20 3.7.1 Tubular armrest, height-adjustable, swiveling... 20 3.7.2 Armrest, stepless height adjustable, removable... 21 3.7.3 Armrest, height adjustable, removable... 21 3.7.4 Armrest, foldable and removable... 22

3.7.5 Armrest, height adjustable, foldable and removable... 23 3.8 Leg rests... 23 3.8.1 Swing away leg rests... 24 3.8.2 Swing away, angle adjustable leg rests... 24 3.9 Anti-tipper... 26 3.10 Tires... 28 3.11 Seat cushion... 28 4 Accessories... 29 4.1 Comfort version... 29 4.2 Transit version... 29 4.3 Dual handrim DHR... 30 4.4 One arm drive by lever... 31 4.5 Posture belt... 32 4.6 Headrest... 34 4.7 Lateral positioning pads (for adjustable backrest cover only)... 35 4.8 Tipper aid... 36 4.9 Table tray... 36 4.10 Half tray... 36 4.11 Add a half tray cushion... 38 4.12 Drip stand... 39 4.13 Transfer kit wheels... 40 4.14 Air pump... 40 4.15 Passive illumination... 41 4.16 Cane holder... 41 5 Setup... 42 5.1 Safety information... 42 6 Using the wheelchair... 43 6.1 Safety information... 43 6.2 Braking during use... 44 6.3 Move to/from the wheelchair... 45 6.4 Driving and steering the wheelchair... 46 6.5 Negotiating steps and kerbs... 47 6.6 Going up and down stairs... 48

6.7 Negotiating ramps and slopes... 49 6.8 Stability and balance when seated... 51 7 Transport... 52 7.1 Safety information... 52 7.2 Folding and unfolding the wheelchair... 52 7.3 Lifting the wheelchair... 53 7.4 Removing and fitting the rear wheels... 54 7.5 Transporting the occupied wheelchair in a vehicle... 55 8 Maintenance... 61 8.1 Safety information... 61 8.2 Maintenance Schedule... 61 8.3 Cleaning... 63 8.4 Disinfection... 64 9 Troubleshooting... 65 9.1 Safety information... 65 9.2 Identifying and repairing faults... 66 10 After Use... 68 10.1 Storage... 68 10.2 Re-use... 68 10.3 Disposal... 68 11 Technical Data... 69 11.1 Dimensions and weight... 69 11.2 Materials... 70 11.3 Environmental conditions... 71

General

1 General

1.2 Symbols in this manual

1.1 Introduction

In this User Manual warnings are indicated by symbols. The warning symbols are accompanied by a heading that indicates the severity of the danger.

This user manual contains important information about the handling of the product. To ensure safety when using the product, read the user manual carefully and follow the safety instructions. Note that there may be sections in this document, which are not relevant to your product, since this document applies to all available models (on the date of printing). If not otherwise stated, each section in this document refers to all models of the product. The models and configurations available in your country can be found in the country-specific price lists. Invacare reserves the right to alter product specifications without further notice. Before reading this document, make sure you have the latest version. You find the latest version as a PDF on the Invacare website. If you find that the font size in the printed document is difficult to read, you can download the PDF version from the website. The PDF can then be scaled on screen to a font size that is more comfortable for you.

WARNING! Indicates a hazardous situation that could result in serious injury or death if it is not avoided. CAUTION! Indicates a hazardous situation that could result in minor or slight injury if it is not avoided. IMPORTANT! Indicates a hazardous situation that could result in damage to property if it is not avoided. Gives useful tips, recommendations and information for efficient, trouble-free use. This product complies with Directive 93/42/EEC concerning medical devices. The launch date of this product is stated in the CE declaration of conformity. Manufacturer

For more information about the product, for example product safety notices and product recalls, contact your Invacare representative. See addresses at the end of this document. 1608467-D

5

Invacare® Action 3 NG

1.3 Warranty

•

Invacare guarantees that their wheelchairs are free from defects and are fully functional. The warranty covers all faults and defects which are verifiably attributable to faulty construction, substandard materials or poor workmanship. Warranty claims against the manufacturer may only be made by the distributor and not by the user of the product.

• •

The warranty does not cover normal wear and tear, the consequences of improper handling or damage, poor maintenance and incorrect assembly or commissioning by the purchaser or a third person or faults which are attributable to circumstances beyond our control. Wearing parts are not covered by the guarantee. The warranty is voided if modifications are made to the product which were not authorized and not performed by the specialist dealer or if inappropriate accessories or spare parts are used. The warranty does not cover consequential costs arising from the rectification of defects such as freight and travel expenses, labor costs, fees etc. The term of the warranty is 24 months. Furthermore, the terms and conditions are part of the general terms and conditions particular to the individual countries in which the product is sold.

1.4 Limitation of liability Invacare accepts no liability for damage arising from: • • • 6

Non-compliance with the User Manual Incorrect use Natural wear and tear

•

Incorrect assembly or set-up by the purchaser or a third party Technical modifications The usage of unapproved 3rd party accessories instead of a tested and approved Invacare accessories Unauthorized modifications and/or use of unsuitable spare parts

A written authorisation of Invacare must be obtained before installing additional adaptations on an Invacare wheelchair. Otherwise no liability claims can be made.

1.5 Standards and Regulations Quality is fundamental to the company’s operation, working within the disciplines of ISO 13485. The wheelchair has been tested in accordance with EN 12183. It includes a test for flammability (EN 1021-2 or ISO 8191-2). Invacare is continuously working towards ensuring that the company’s impact on the environment, locally and globally, is reduced to a minimum. We use only REACH compliant materials and components.

1.6 Intended use The medium active wheelchair is propelled manually and should only be used for independent or assisted transport of a disabled person with mobility difficulties. This manual wheelchair is intended to provide mobility to persons ages 15 and up (adolescents and adults) with a maximum weight capacity of 125 kg. The device is indicated to provide mobility to persons limited to sitting position. When used without an assistant, it should only be used by persons who 1608467-D

General

are physically and mentally able to use the wheelchair safely (e.g. to propel themselves, steer, brake). The wheelchair should only be used on level ground and accessible terrain, as well as indoors. This medium active wheelchair needs to be subscribed and fit to your specific health condition. WARNING! Any other or incorrect use could lead to hazardous situations. There are no contraindications known, when using the wheelchair as intended. CAUTION! – In some configurations, the overall dimensions of the wheelchair when it is ready for use exceed the authorized limits, the access to emergency escape routes is not possible. – In some configurations, the wheelchair exceed the size recommended for travelling by train in the EU. Theft and metal detection systems: in seldom cases the materials used in the wheelchair may activate theft and metal detection systems.

1.7 Service life The expected service life is five years, presuming that the product is used daily and in accordance with safety instructions, maintenance instructions and intended use, stated in this manual. 1608467-D

7

Invacare® Action 3 NG

2 Safety 2.1 Safety information This section contains important safety information for the protection of the wheelchair user and assistant and for safe, trouble-free use of the wheelchair. WARNING! Risk of accidents and serious injury Accidents with resulting serious injury can occur if the wheelchair is wrongly adjusted. – Adjustments at the wheelchair always must be carried out by an authorized dealer. WARNING! Risk due to driving style being unsuitable for the conditions There is a risk of skidding on wet ground, gravel or uneven terrain. – Always adjust your speed and driving style to the conditions (weather, surface, individual ability, etc.). WARNING! Risk of injury In a collision you could sustain injury to parts of your body that extend beyond the wheelchair (e.g. feet or hands). – Avoid an unbraked collision. – Never drive into an object head-on. – Drive carefully through narrow passages. 8

WARNING! Risk due to wheelchair being out of control At high speed you could lose control of your wheelchair and overturn. – Never exceed a speed of 7 km/h. – Avoid collisions in general. WARNING! Risk of tilting The position of the rear wheel axle and the angle of your wheelchair’s backrest are two of the key adjustments that can affect your stability whilst sitting in the wheelchair. – These changes, any front wheels position and/or angle fork adjustments to the set-up of your wheelchair must only be performed at the direction of a competent person who has fully risk assessed the implication of any changes to the wheelchair configuration. Therefore, consult with your authorized dealer. CAUTION! Risk of burning The wheelchair components can heat up when exposed to external sources of heat. – Do not expose the wheelchair to strong sunlight before use. – Before usage, check all components that come into contact with your skin for their temperature.

1608467-D

Safety

CAUTION! Risk of getting fingers caught There is always a risk of getting, e.g. fingers or arms, caught in the moving parts of the wheelchair. – Make sure when activating the folding or insertion mechanisms of moving parts, such as the removable axle of the rear wheel, folding backrest or anti-tipper, that nothing becomes caught. CAUTION! Risk of tipping The hanging of additional load (back pack or similar items) onto your chair backposts can affect the rearward stability of your wheelchair, especially when used in combination with angle adjustable backrests. – Invacare strongly recommend the use of anti-tipper (available as an option) when using your backposts with additional load.

2.2 Safety devices WARNING! Risk of accidents Safety devices that are incorrectly set or no longer working (brakes, antitipper) can cause accidents. – Always check that the safety devices are working before you use the wheelchair and have them checked regularly by the authorized dealer. 1608467-D

The functions of the safety devices are described in chapter 3 Components and their functions, page 11.

2.3 Labels and symbols on the product Identification label The identification label is attached to the frame of your wheelchair and gives the following information:

A

Manufacturer’s address

B

Product description

C

Date of manufacture

D

CE mark

E

Maximum user weight

F

Part number

G

Serial number barcode

H

Serial number 9

Invacare® Action 3 NG

Read user manual Indicates a hazardous situation that could result in serious injury or death if it is not avoided. Snap hook symbols Depending on the configuration, some wheelchairs may be used as a seat in a motor vehicle, some may not.

ISO 717 6-19

Tie-down positions where the restraint system straps must be placed in case of using the wheelchair as a seat in a motor vehicle, see section 7.5 Transporting the occupied wheelchair in a vehicle, page 55. WARNING Symbol This wheelchair is not configured for passenger transport in a motor vehicle. This symbol is attached to the frame close to the identification label.

10

1608467-D

Components and their functions

3 Components and their functions 3.1 Overview

A

Push handle

B

Back

C

Rear wheel with handrim

D

Parking brake

E

Front wheel fork with front wheel

F

Leg rests, swiveling

G

Footrest

H

Frame

I

Seat

J

Armrest

Short description This is a medium active wheelchair with crossbar folding mechanism and swiveling leg rests. The equipment of your wheelchair may differ from the diagram as each wheelchair is manufactured individually to the specifications in the order.

1608467-D

11

Invacare® Action 3 NG

3.2 Parking brakes

CAUTION! Risk of pinching or crushing There may be a very small gap between the rear wheel and the parking brake with the risk that you could trap your fingers. – Keep your fingers away from movable parts when using the brake, always keep your hand on the brake lever.

The parking brakes are used to immobilize the wheelchair when it is stationary to prevent it from rolling away. WARNING! Risk of overturning if you brake sharply If you apply the parking brakes while you are moving, the direction of movement can become uncontrollable and the wheelchair may stop suddenly, which can lead to a collision or to you falling out. – Never apply the parking brakes while you are moving.

The distance between the brake shoe and the tire can be adjusted. The adjustment must be carried out by an authorized dealer. Standard brake

WARNING! Risk due to wheelchair being out of control – The parking brakes must be operated simultaneously. – Do not apply the parking brakes to slow down the wheelchair. – Do not lean on the parking brakes for support or transfer. WARNING! Risk of overturning The parking brakes will not operate correctly unless there is sufficient air in the tires. – Ensure the correct tire pressure, 3.10 Tires, page 28.

12

1. 2.

To apply the brake, push the brake lever forwards with the palm as far as possible. To release the brake, pull the brake lever backwards with the low fingers.

1608467-D

Components and their functions

The lever of the push handle can be folded back to facilitate transfers. To do so, pull up the lever and fold it backwards.

3.3.1 Backrest cover You can adjust the tension of the backrest cover as required. Adjusting the backrest cover

Pull brake

1. 2.

To apply the brake, pull the brake lever backwards with the low fingers as far as possible. To release the brake, push the brake lever forwards with the palm. The lever of the push handle can be folded back to facilitate transfers. To do so, pull up the lever and fold it backwards.

One arm drive push brake (available as an option) This push brake allows the user to immobilise the wheelchair with a single arm (One brake lever; right or left hand).

3.3 Backrest There are three types of backrest (Fixed, Folding and Reclining) available. 1608467-D

1. 2. 3.

Remove the backrest cushion A. Loosen the hook and loop strips B on the rear of the backrest cover by simply pulling on them. Tighten or loosen the strips as required then reattach them. WARNING! Risk of tipping If the bands are set very loose, the tipping point of your wheelchair is changed for the worse. – Ensure that the bands are set correctly. IMPORTANT! – Do not overtighten the bands; this is to ensure that the geometry of the wheelchair is not changed. 13

Invacare® Action 3 NG

IMPORTANT! – Only ever tighten the bands when the wheelchair is unfolded. A simple backrest cover is available for all backrest types. These covers are not adjustable. 3.3.2 Backrest cover height

3.3.3 Fixed backrest Fixed backrest of 0° and 7°: these two backrests do not require adjustments. 3.3.4 Folding backrest To save space for transporting the wheelchair, the backrest can be folded.

The backrest cover height can be adjusted for all three types of backrest. WARNING! Risk of tipping The hanging of additional load (back pack or similar items) onto your wheelchair back posts can affect the rearward stability of your wheelchair. This can cause the chair to tip backwards causing injury. – Therefore, Invacare strongly recommend the use of anti-tippers (available as an option) when using your back posts with additional load (back pack or similar items).

Folding and unfolding the backrest 1.

The height of the backrest cover can be adjusted on the back posts. The adjustment must be carried out by an authorized dealer.

14

2.

Operate lever A by pulling it and fold the top of the backrest. To return to the initial position, bring the top in the vertical position; it locks automatically.

1608467-D

Components and their functions

3.3.5 Reclining backrest

WARNING! Risk of injury – Always make these adjustments before the user settles down in the wheelchair to prevent injuries. – Invacare strongly recommends the use of anti-tippers (available as an option) in combination with all rear wheel positions when you use your backrest with an angle of 12° and more

To achieve a more comfort position for the user, the backrest can be reclined.

WARNING! Risk of tipping Do not move the wheelchair when the backrest is in reclined position. – Invacare strongly recommend the use of anti-tippers (available as an option) when the backrest is in reclined position .

IMPORTANT! – Push on the backrest canes before operating the levers, this is to release the auto-locked security system. 1. 2. 3.

Release the auto-locked system by pushing on the backrest canes. Simultaneously pull the levers A to provides the same angle on both sides. Release the levers when you reach the desired angle.

Backrest angle The angle of the backrest can be adjusted in four steps (0° to 30°) with the mechanical version, and stepless with the gas struts version.

1608467-D

15

Invacare® Action 3 NG

3.3.6 Angle adjustable backrest (-15°/+15°) The angle of the backrest can be adjusted from –15° to +15° (step less).

WARNING! Risk of tipping Do not move the wheelchair when the backrest is in reclined position. – Invacare strongly recommend the use of anti-tippers (available as an option) when the backrest is in reclined position . WARNING! Risk of injury – Invacare strongly recommends the use of anti-tippers (available as an option) in combination with all rear wheel positions when you use your backrest with an angle of 12° and more

1. 2. 3. 4.

Adjust the backrest angle thanks to the adjustable screw A. Turn 5 mm Allen key clockwise to obtain a negative angle. Alternatively, turn 5 mm Allen key anti-clockwise to obtain a positive angle. Ensure both adjustments to the desired angle are equal on both sides.

Invacare recommends that the backrest angle adjustment is carried out by an authorized dealer.

16

WARNING! Risk of serious injury Tilting up with a user of more than 125 kg can fatigue, bend or break the wheelchair backrest. – Avoid tilting up the wheelchair with a user weight of more than 125 kg. CAUTION! Risk of uncomfortable posture An angle less than 90° between the seat and the backrest is uncomfortable for certain users. – This adjustment must be performed by a professional technician upon agreement by a prescribing physician. Please consult with your dealer. 1608467-D

Components and their functions

3.4 Backbrace

1.

There are two types of backbraces (Standard backbrace and Folding backbrace) available.

2.

3.4.1 Standard backbrace for the backrest

Unfolding the backbrace

The backbrace links the two push handles, provides tension to the backrest upholstery and must always be in position on recliner versions.

1. 2.

CAUTION! – Do not use the backbrace to push the wheelchair. The backbrace is not a push bar! – Do not attempt to lift the wheelchair using the backbrace; it may come loose and it could break. – Keep your fingers away from movable parts and sharp edges to prevent injuries.

3.

Slightly loosen the two hand screws A, pull up the backbrace B and swivel it downwards along the backrest (on right or left hand). Fold the backbrace B until it is in vertical position.

Fold the backbrace B upwards. Align the backbrace B with the push handle and push it down on the hand screw A. Firmly tighten the hand screw A and make sure that the TWO hand screws A are properly tightened. It is important to ensure that the backbrace is correctly fitted and engaged at all times when the chair is in use. It should not be left hanging loose (see label C on the backbrace).

Folding the backbrace

1608467-D

17

Invacare® Action 3 NG

3.4.2 Folding backbrace for the backrest

3.5 Push handles

An optional folding backbrace is available to increase the rigidity of the backrest on wheelchairs with large back heights or widths. CAUTION! – Do not use the folding backbrace to lift or push the wheelchair. It could break. Folding the backbrace

IMPORTANT! – Always check the push handles before using the wheelchair, as to whether the hand grips are secure, cannot be turned and cannot be pulled off. Height adjustable, rear set push handles (optional) The height adjustable, rear set push handles allow any assistant to adjust the handles to a comfortable level.

A

1. 2.

Unlock the folding backbrace by pushing the joint A slightly downwards. Fold the backbrace downwards. The folding backbrace will automatically release when the chair is folded.

Unfolding the backbrace 1. 2. 18

1.

To set the height of the push handles, loosen the knob A, push the handle to the desired position and tighten the knob again.

Fold the backbrace upwards. Lock the folding backbrace by pulling the joint A slightly upwards. 1608467-D

Components and their functions

CAUTION! If the knob is not correctly tightened, the push handle could accidentally come off the backrest tube while pushing it upwards. – Make sure that the knob is firmly tightened.

CAUTION! If the knob is not correctly tightened, the push handle could accidentally come off the backrest tube while pushing it upwards. – Make sure that the knob is firmly tightened.

Height adjustable, integrated push handles (optional)

3.6 Mudguard

The height adjustable, integrated push handles allow any assistant to adjust the handles to a comfortable level.

In order to prevent dirt from the wheels spraying upwards, a removable mudguard can be fitted. The position of the mudguard can be adjusted.

Removing 1.

To set the height of the push handles, loosen the knob A, push the handle to the desired position and tighten the knob again.

1. 2.

Pull the mudguard upwards out of the holder. To adjust how easy or difficult it is to pull the mudguard out of the holder, change the degree to which the screws D are tightened.

Fitting 1. 1608467-D

Push the mudguard into the holder. 19

Invacare® Action 3 NG

Adjusting the height 1. 2. 3. 4.

3.7.1 Tubular armrest, height-adjustable, swiveling

Loosen the screw B with 10 mm spanner in the groove C of the armrest tube. Move the armrest upwards or downwards until you reach the desired height, while keeping screw B in place (at the top edge of the holder). Tighten the screw B (5–6 Nm). Perform the setting on both sides.

3.7 Armrests WARNING! The armrest does not engage into the wheelchair. – Therefore do not hold it in order to lift the wheelchair. CAUTION! Risk of pinching – Keep your fingers away from movable parts during removing, fitting or adjusting the armrest.

Removing 1.

Raise the tubular armrest and pull it upwards out of the holder.

Fitting 1.

Push the tubular armrest into the holder.

Adjusting the height 1. 2. 3. 4.

Pull the tubular armrest out of the holder. Loosen the screw on the tube of the armrest and screw it back in at the desired height. Push the tubular armrest back into the holder. Perform the setting on both sides.

Swiveling 1. 20

Raise the armrest a little and swivel it outwards. 1608467-D